chap 傳熱傳質1.3

華中科技大學 力學系 傳熱傳質學 2014 Spring Introduction: Conservation of EnergyChapter OneSection 1.3華中科技大學 力學系 傳熱傳質學 2014 Spring Alternative Formulations Alternative FormulationsTime Basis:At an instantorOver a time intervalType of System:Control volumeControl surface An important tool in heat transfer analysis, often providing the basis for determining the temperatureof a system.CONSERVATION OF ENERGY(FIRST LAW OF THERMODYNAMICS)華中科技大學 力學系 傳熱傳質學 2014 Spring At an Instant of Time:Note: representation of system by a control surface (dashed line) at the boundaries.Surface PhenomenaVolumetric PhenomenaConservation of Energy(1.11c)Each term has units of J/s or W.APPLICATION TO A CONTROL VOLUME Over a Time IntervalEach term has units of J.(1.11b)CV at an Instant and over a Time Interval華中科技大學 力學系 傳熱傳質學 2014 Spring At an instant Special Cases (Linkages to Thermodynamics)Transient Process for a Closed System of Mass (M) Assuming Heat Transfer to the System (Inflow) and Work Done by the System (Outflow).Over a time intervalClosed SystemFor negligible changes in potential or kinetic energyInternal thermal energy華中科技大學 力學系 傳熱傳質學 2014 Spring Example 1.3: Application to thermal response of a conductor with Ohmic heating (generation): Involves change in thermal energy and for an incompressible substance. Heat transfer is from the conductor (negative ) Generation may be viewed as electrical work done on the system (negative ) Example 1.3華中科技大學 力學系 傳熱傳質學 2014 Spring Example 1.5: Application to isothermal solid-liquid phase change in a container:Latent Heatof FusionExample 1.5華中科技大學 力學系 傳熱傳質學 2014 Spring Steady State for Flow through an Open System without Phase Change or Generation:At an Instant of Time:Open System華中科技大學 力學系 傳熱傳質學 2014 Spring Surface Energy BalanceA special case for which no volume or mass is encompassed by the control surface.Conservation Energy (Instant in Time): Applies for steady-state and transient conditions.Consider surface of wall with heat transfer by conduction, convection and radiation. With no mass and volume, energy storage and generation are not pertinent to the energy balance, even if they occur in the medium bounded by the surface.THE SURFACE ENERGY BALANCE華中科技大學 力學系 傳熱傳質學 2014 Spring Methodology On a schematic of the system, represent the control surface bydashed line(s). Choose the appropriate time basis. Identify relevant energy transport, generation and/or storage termsby labeled arrows on the schematic. Write the governing form of the Conservation of Energy requirement. Substitute appropriate expressions for terms of the energy equation. Solve for the unknown quantity.METHODOLOGY OF FIRST LAW ANALYSIS華中科技大學 力學系 傳熱傳質學 2014 Spring Problem 1.43: Thermal processing of silicon wafers in a two-zone furnace.Determine (a) the initial rate of change of the wafertemperature and (b) the steady-state temperature.Problem: Silicon WaferSCHEMATIC: 華中科技大學 力學系 傳熱傳質學 2014 Spring Problem: Silicon Wafer (cont.)or, per unit surface area華中科技大學 力學系 傳熱傳質學 2014 Spring Problem: Silicon Wafer (cont.)華中科技大學 力學系 傳熱傳質學 2014 Spring Problem: Cooling of Spherical Canister (cont.)Problem 1.48: Cooling of spherical canister used to store reacting chemicals.Determine (a) the initial rate of change of the canister temperature,(b) the steady-state temperature, and (c) the effect of convectionon the steady-state temperature.535 J/kgK華中科技大學 力學系 傳熱傳質學 2014 Spring Problem: Cooling of Spheri